Displaying items by tag: carrera gts
Your 924, 944 or 968 is in the best of hands at JMG Porsche, where even with servicing we go beyond the factory schedule.
The factory schedule for many models called for a service every two years, which was fine when the car was new and to make the car last beyond the factory warranty without issue. However we strongly recommend that all models are serviced annually, alternating between a minor and a major service each year. Click here and read our article for more information.
Here is a breakdown of our servicing.
Minor servicing (12,000 Mile Service or every other year)
Pre service test drive (JMG Additional included item)
Fault code analysis (models after 1988)
Replacement of the oil filter and engine oil (Porsche approved oil)
Factory specified inspection of - the vehicle under side, engine compartment, coolant hoses, coolant (level and condition), radiator or radiators, air intake, brake system, brake hoses, brake lines, drive shafts, tyres, locks and latches, electrical equipment, horn, windscreen wiper washing system, power steering and fluid level, lighting system check (including headlights and indicators)
JMG Inspection of additional items which are common issues as this model ages (JMG Additional included item)
Final test drive to check all major safety, comfort and mechanical systems for correct operation.
Final fluid and levels check
Courtesy interior vacuum and wash (JMG Additional included item)
Major servicing (24,000 Mile Service or every other year)
All items from minor servicing, plus...
Replacement of the air cleaner element
Check condition, lubricate and adjust if required - fuel system, parking brake, clutch, steering gear, tie rod ends, axle joints, running gear, exhaust system, suspension, seat belts, throttle actuation and auxillary drive belt.
- Numerous additional JMG Specific inspection and adjustments which are model specific, added as the car's get older.
Prices for 924, 944 and 968 Servicing.
924, 944 and 968 (All models) - Minor Service £275 - Major Service £350
All services are performed with Porsche approved oil and genuine OEM filters.
The importance of routine annual servicing.
Routine annual servicing will benefit your car from being inspected by an expert every year, which will certainly mean that many problems are spotted long before they turn into an expensive problem, a simple seal for example, costing only a few pennies, could be all that needs to be spotted and rectified to avoid a complete engine failure.
Beyond this, on more modern models where the servicing is specified by the factory for every two years, there is evidence that that has decreased the long term reliability of components. A good example of this are the engine oil hydraulic components on a Porsche 997 being the same parts as used in a Porsche 996, yet the 996 rarely suffers from variocam solenoid failures, but those of the 997 are frequent and can cost thousands of pounds to repair, just for the sake of regular yearly servicing and oil changes.
Some people only cover a few miles per year and therefore believe their car will not need regular annaul servicing, however this also can cause problems.
We have many menu prices for Porsche repairs of each model which are usually likely to cost more if performed with our hourly rate, call us for a price.
For anything else our repairs hourly rate is £79.95 per hour.
Menu price diagnostic appointment - £149.20 (Two hours)
Porsche cars are especially sophisticated and complicated cars, therefore diagnosis needs to be performed by expert Porsche specialist diagnostic technicians, the cream of the crop, even for what might seem like very simple faults.
With all faults, there will be a problem, such as a bad relay for example, as well as this there will be a cause, perhaps this cause would be what caused the relay to become faulty, which in itself could be abstract or unusual, or could be as simple as age, but it is still important to be reasonably sure of the cause, before new parts are installed, otherwise the new parts will also swiftly expire!
Even with the most expert technicians it is impossible to predict what the fault may be, until we have spent some time both diagnosing what is faulty and what has caused that item to be faulty, so to be professional at what we do, in some cases we may need to spend a longer duration of time with our investigations.
Unfortunately, this can mean that diagnosis can be very time consuming and therefore expensive, as well as difficult to schedule in our busy workshop.
With this in mind we have developed a clinic system for diagnostic visits, where we charge £149.20 for a two hour appointment. During which the following will happen.
The customer will be able to talk to the diagnostic technician in person to explain the fault.
The diagnostic technician will endeavour to recreate the fault to experience it in person, perhaps including a test drive with the customer.
The diagnostic technician will then begin tests to narrow down the fault, which may include using the Porsche diagnostic computers, or even our special diagnostic equipment not available elsewhere, studying the engineering documentation, technical service bulletins as well as running manual tests on or off of a vehicle lift.
In the case of the problem being simple, it may even be possible that within this phase the problem may be found, the cause clear and perhaps even a repair made.
Once complete, before the two hour appointment is exhausted, the technician will spend time with the customer explaining what he has found, as well as what additional diagnosis may need to be performed, how long that may take, and what potentially could be the causes of the problem, concluding with an appointment made for when the further diagnosis or repairs can be made.
Between the end of this visit and the appointment for continuation of the repairs or diagnosis, the car can be taken away, or left with us by mutual agreement.
ALL PRICES ARE PLUS VAT
Interesting service and repair information for the Porsche 924, 944 and 968 models.
Service interval - Even though the service book specifies six monthly and yearly services. We would strongly recommend that all Porsche models are serviced at least yearly or every 10,000 miles if more than 10,000 miles are covered per year to avoid expensive repairs and to potentially catch issues early, where they may be less expensive to repair.
Engine failures - Not as common as you would expect, we at JMG Porsche have never had to replace one of these engines due to wear, however we have had to replace many due to insufficient servicing and maintenance, but there are still worthwhile ways of avoiding unexpected large engine rebuild costs. One of which is proper servicing by a real Porsche specialist, which may not need cost as much as you think. There are also some ways to avoid unexpected bills by following some of our other advice bellow.
Brake fluid - Did you realise this should be changed every two years? Not doing this can cause problems with expensive parts within your car, such as the ABS pump or any part of the brake hydraulics due to water contamination as the brake fluid actually sucks moisture out of the air (hydroscopic), so even if the car is not used, the brake fluid must be changed every two years!
Water Pump - Often thought of as a part which fails with age, mileage and quite suddenly, leaving you stranded, our expert technicians are used to inspecting these during services, and so may spot tell tale signs of failure long before they become an issue, so saving you from the indignity of being broken down at the side of the road. A 944 and 968 Waterpump is also part of the cambelt drive mechanism, so it failing can cause serious damage to the cylinder head and engine as a whole.
RMS - Rear main seal - Something else you might see horror stories on the internet about, these used to be a real problem and Porsche re designed the part several times to arrive at the current design which is the only one we at JMG Porsche use. Like an IMS Bearing replacement, this is best performed during a clutch change, however on tiptronic models or on cars not needing a clutch, they can be changed at any time.
Transmission services - Not clearly noted by Porsche for when the transmission should be serviced and this vital expensive part of your car should not be overlooked. Just like your engine, the transmission is filled with oil/transmission fluid, which over time degrades. Not only this, but not many realise that many Porsche transmissions also contain a filter, which becomes clogged over time and can starve your transmission of lubrication, causing expensive repairs. We recommend all Porsche transmissions are serviced every 4 years or 40,000 miles, whichever comes soonest.
Diagnosis - Long has gone where cars had limited electrical equipment and a wiring diagram could be found in a manual from Halfords. Now the Porsche models have multiple separate computer systems, which all talk via networks, and many sensors to feed those computers with information about the world around it all tied together with many hidden wiring looms of thousands of wires and connectors. This can mean that in the event of your Porsche suffering an electrical issue, it is important that a Porsche specialist auto electrician is available, as we have at JMG Porsche. It is also important to understand that sometimes, finding the fault will not be as simple as plugging in a computer.
Drive Belt - Many of you may have had cars where a drive belt, timing belt or cam belt needs to be changed at a regular interval. Your Porsche model has a belt which should be changed every 4 years. Failure to do so can cause instant overheating, loss of power steering and damage to the engine very suddenly. We recommend you have this changed at least every 4 years.
Cam and Balance belt - The 924S, 944 (ALL) and 968 (ALL) have a cam belt and balance belt, which has to be set to a very precise tension and run across various pulleys, tensioners and rollers to function correctly, if these are not maintained with a new cam belt and balance belt every 4 years, and a new waterpump, tensioners and rollers (as well as front engine oil seals) every 8 years, the consequences can be catastrophic to say the least.
Brakes - The Porsche 944S2, 944 Turbo and all 968 models are fitted with Brembo callipers, which overtime suffer from corrosion build up which can cause the pads to stick and bind up within the callipers or even make it difficult to fit new pads. When this happens the calipers require a service rebuild of the slider plate mechanism, which needs to be performed by a specialist with the right experience, techniques and tools to make the repair more than a very temporary one.
Heavy clutch? - A heavy feeling clutch which is stiff to use is not normal on a Porsche and often a sign that the clutch has almost worn out. Ignoring this can cause further damage, such as to the dual mass flywheel and clutch fork.
Alarm system - At JMG Porsche we are experts of all Porsche security systems and have reverse engineered all the various control units. This not only means we can program new alarm control units and keys to your car, just as the main dealer can, but in some cases we can repair your old alarm control unit and keys, or in some cases recover your old keys to be used on the new alarm control unit, which is a service unique to JMG.
Alarm system causes - In most cases the cause of alarm control unit failure is water damage, we can perform modifications to your Porsche model to help mitigate the chances of this happening to your Porsche.